Hauptbild Name Hersteller Typ Größe Kapazität

Papiertütenmaschine Honsel

Dimensions of bags:

Width:           8 -25 cm

Length:        20 - 40 cm 

With or without a gusset

Paper bags with V - bottom

2 colours printing line

Honsel up to 200 bags per minute, depending on size and paper

Kraftliner Karton Papiermaschine 2950 mm

 Kraftliner paper machine 2950 mm

Basis Weight: 170 g/m² - 500 g/m²

Machine speed: 120 m/min (200 g/m²)

Paper Width: 2,950 mm

Capacity: 100 tpd


2950 mm 100 tpd

Paper machine 2550 mm

machine width: 2550mm

Max. speed: 200 m/min

BW range: 30-400grs/m²

Supply voltage: 3 x 500 Volts

Steam pressure: 4 bar

Air pressure: 7 bar

Water pressure: 2 bar

Water consumption: 40 Lts/Kg

Steam consumption: 3.0 Kg/kg

PM only from headbox to pope-roll.



Has produced a wide range of products:
Fine papers, 60 to 220 GSM with watermark and deep colors. High quality board papers up to 400 GSM
Other specialty papers from 30 to 90 GSM

Production range is from 30 to 400 GSM running at 50 to 220 m/min.

Paper with at reel is 2550 mm max.

Capacity is up to 3500 Kg/h.

Main characteristics is its formation uniformity CM and MD, gradual drying rate both wet and steam dried.



It is a Fourdrinier type with removable table for wire change, cantilever couch roll, closed headbox for optimal flow rate at any speed and watermarking Dandy Roll.


Three 80 kg /cm2 presses, 2 lower felt and a 3rd upper felt, allowing good drying capacity and surface smoothing.

Water content after presses is about 50% below 120 GSM.


Consist in a main battery of 18 driers of 1250 mm diameter, in 3 drive sections with drying felts on both sides.

Post drying after size press is done with 6 driers, 4 of 1000mm dia and 2 1250mm diameter in one drive section, with automatic paper moisture control.

All driers tested at 4 Bar, heated with steam at 3.7 Bars max.

All sections covered by a recovery heat hood that allows pocket ventilation at 90 degrees Celcius.


Two rubber 350 mm diameter rolls working at 20 Kg/cm allows sizing with starch and latex.


Küsters 400mm dia King roll, 2 intermediate 330mm dia rolls and un upper 400mm dia Queen roll that can be used as a one pass or three pass calender up to 80 Kg/cm.


It is a line shaft with conical pulleys, pneumatic clutch and angular reducer for 11 sections. Motor drive is 300 Kw dc.


  • ·  Deckle : 2,55m
  • ·  Max Speed : 220m/min
  • ·  Basis weight range : 40/400gsm
  • ·  Headbox : pressurized / Stainless steel built in 2003
  • ·  Fourdrinier with foils, 6 vacuum boxes, Couch Roll with vacuum
  • ·  2 vertical presses with bottom felt – max 80kg/cm
  • ·  1 vertical presses offset – max 80kg/cm
  • ·  18 Drying cylinder – Diameter 1,25 m – 3,7 ata steam pressure
  • ·  Inclined Size-Press – working pressure 20kg/cm
  • ·  6 Drying cylinder – Diameter 4×1,0m + 2×1,25 m – 3,7 ata steam pressure
  • ·  High efficiency hood
  • ·  Machine Calender – 3 NIPs – Kuster bottom roll
  • ·  Vertical Reel up (Pope
  • ·  ABB supervision & gauges for Moisture & basis weight control


  • Product portfolio
  • 1). security papers, like for checkbooks, fiscal stamps, minutes for notaries
  • 2.) papers for wine labels,
  • 3.)  bristol cardboard for various commercial applications, like posters, bookstore, 
  • 4.) papers with watermark, 
  • 4.) plasterboard


  • Operational Features: The very versátiles headbox with both option to run either with vacuum or with pressure between 0.5 abd 1.15 % of consistency and a forming table with a vacuum system, that let the operators to work with less or more water on the table…


  • It had a very flexible, multiple  vacuum system, where you could easaly regulate the amount of water to handled on the table…


  • Production Mix : ThePM was continuously switching from one grade to another,  between 40 and 330 gr/sqm of basisweight. 
2550mm 3,5 t/h

Several different tissue paper converting machines

1. Automatic handkerchief production line - fully automatic. Productivity – 35 packs per minute.

2. Bandsaw with self-sharpening tape for cutting toilet paper and kitchen rolls.

3. Napkin machine with one printing section. Productivity: 500 pieces per minute.

4. Napkin machine with two printing sections.  Productivity: 600 – 650 pieces per minute.

5. Napkin machine. Productivity: 650 – 700 pieces per minute.

6. Production line for cardboard spools. Capacity: 12 meters/~39ft per minute.

7. Production line for toilet paper and kitchen towel rolls. Productivity: 90 tons/198,416 lbs per month.

8.Production machine for toilet paper and kitchen towel rolls with Deco system and lamination. Productivity: 90 tons/198,416 per month.

9. Production machine for toilet paper and kitchen towel rolls. Productivity: 150 tons/330,693 lbs per month.

10. Production machine for V-shaped hand towels with a vacuum-folding system.

Productivity: 1) V – hand towels – 450 pieces per minute. 2) V - fold toilet paper 3x17g / 3x0.60oz - 450 pieces per minute.

11. Unrolling and slitting machine for sanitary paper. Productivity: 4000 – 5000 kilograms/8,818 - 11,023 lbs daily.

Several different tissue paper converting machines

Fiber production equipment TMP/CTMP/BCTMP

Fiber production equipment BCTMP

Manufacturer: Andritz, Taufel&Co, Ahlstrom, FMW, Jylhavara, Bauer, Metso/Sound

Fiber line start-up: first start up as NSSC line in 1986, part of them as a new started up in 1994

Major rebuild: 1994 – origin NSSC was rebuilded to TMP/CTMP/BCTMP, before start up, refiners was send to Austria to Andritz for overhoul.

Capacity:Up to 210 bdmt/day, Spruce species.

Condition: fiber line still under operation untill to September 2024 when main equipment be dismantled and replaced by new

Andritz, Taufel&Co, Ahlstrom, FMW, Jylhavara, Bauer, Metso/Sunds



Rollenverpackungsanlage Lamb 1800 mm breit

Max. Rollendurchmesser  1,45 m
20 Rollen pro Stunde Kapazität
Betrieb mit  1 Mann ist möglich
max  Rollenbreite 1,8 m

Lamb 1800 mm width max 20 Rolls per hour

Headbox made by Voith for different paper grades

Box width: 2600 mm

Modules quantity: 40

Capacity: 10.000 - 24.000 l/min

Operating speed: 480 - 1.000 m/min

Voith 1000 m/min pm speed

Stoffauflaufpumpe Voith 1000 l/sek

Gebrauchte Stoffauflaufpumpe vom Hersteller Voith

P= 600KW

Q= 1000l/s

H= 34m

n= 1450 min -1

Saug- und Druckflansch beidseitig

Der Laufraddurchmesser: Ca. 580 mm

Das Material des Pumpengehäuses: Bronze

Voith 1000 l/sec

Gas turbine plant including generator & waste heat boiler4600 kw


year of construction: 1990 es

Electrical output: 4.600 kWel

Speed: 14.944min.-1 50Hz

Fuel: natural Gas H

Turbine inlet temperature: 665°C (1.229°F)


Generator (in the package)

Manufacturer: ABB

Type: 3 phase synchronous

Year of manufacturing: 1990 ies

Rated power: 6.000 kVA

Speed: 1.500 rpm

Cos phi: 0.98 (nominal 0.8)

Frequency: 50 Hz

Rated voltage: 10.5 kV