PM Grafisches- / Verpackungspapier

Hauptbild Name Hersteller Typ Größe Kapazität

Paper machine 2550 mm

machine width: 2550mm

Max. speed: 200 m/min

BW range: 30-400grs/m²

Supply voltage: 3 x 500 Volts

Steam pressure: 4 bar

Air pressure: 7 bar

Water pressure: 2 bar

Water consumption: 40 Lts/Kg

Steam consumption: 3.0 Kg/kg

PM only from headbox to pope-roll.

 

MACHINE DESCRIPTION

Has produced a wide range of products:
Fine papers, 60 to 220 GSM with watermark and deep colors. High quality board papers up to 400 GSM
Other specialty papers from 30 to 90 GSM

Production range is from 30 to 400 GSM running at 50 to 220 m/min.

Paper with at reel is 2550 mm max.

Capacity is up to 3500 Kg/h.

Main characteristics is its formation uniformity CM and MD, gradual drying rate both wet and steam dried.

GENERAL DESCRIPTION

FORMING SECTION WITH DANDY ROLL

It is a Fourdrinier type with removable table for wire change, cantilever couch roll, closed headbox for optimal flow rate at any speed and watermarking Dandy Roll.

PRESSES

Three 80 kg /cm2 presses, 2 lower felt and a 3rd upper felt, allowing good drying capacity and surface smoothing.

Water content after presses is about 50% below 120 GSM.

DRYING

Consist in a main battery of 18 driers of 1250 mm diameter, in 3 drive sections with drying felts on both sides.

Post drying after size press is done with 6 driers, 4 of 1000mm dia and 2 1250mm diameter in one drive section, with automatic paper moisture control.

All driers tested at 4 Bar, heated with steam at 3.7 Bars max.

All sections covered by a recovery heat hood that allows pocket ventilation at 90 degrees Celcius.

SIZE PRESS

Two rubber 350 mm diameter rolls working at 20 Kg/cm allows sizing with starch and latex.

CALENDER STACK

Küsters 400mm dia King roll, 2 intermediate 330mm dia rolls and un upper 400mm dia Queen roll that can be used as a one pass or three pass calender up to 80 Kg/cm.

MACHINE DRIVE

It is a line shaft with conical pulleys, pneumatic clutch and angular reducer for 11 sections. Motor drive is 300 Kw dc.

SECURITY PAPER MACHINE

  • ·  Deckle : 2,55m
  • ·  Max Speed : 220m/min
  • ·  Basis weight range : 40/400gsm
  • ·  Headbox : pressurized / Stainless steel built in 2003
  • ·  Fourdrinier with foils, 6 vacuum boxes, Couch Roll with vacuum
  • ·  2 vertical presses with bottom felt – max 80kg/cm
  • ·  1 vertical presses offset – max 80kg/cm
  • ·  18 Drying cylinder – Diameter 1,25 m – 3,7 ata steam pressure
  • ·  Inclined Size-Press – working pressure 20kg/cm
  • ·  6 Drying cylinder – Diameter 4×1,0m + 2×1,25 m – 3,7 ata steam pressure
  • ·  High efficiency hood
  • ·  Machine Calender – 3 NIPs – Kuster bottom roll
  • ·  Vertical Reel up (Pope
  • ·  ABB supervision & gauges for Moisture & basis weight control

 

  • Product portfolio
  • 1). security papers, like for checkbooks, fiscal stamps, minutes for notaries
  • 2.) papers for wine labels,
  • 3.)  bristol cardboard for various commercial applications, like posters, bookstore, 
  • 4.) papers with watermark, 
  •  
  • 4.) plasterboard

 

  • Operational Features: The very versátiles headbox with both option to run either with vacuum or with pressure between 0.5 abd 1.15 % of consistency and a forming table with a vacuum system, that let the operators to work with less or more water on the table…

 

  • It had a very flexible, multiple  vacuum system, where you could easaly regulate the amount of water to handled on the table…

 

  • Production Mix : ThePM was continuously switching from one grade to another,  between 40 and 330 gr/sqm of basisweight. 
2550mm 3,5 t/h

Langsieb-Papiermaschine 4200 mm

Gebrauchte corrugated medium Papermaschine:

Type: fourdrinier

Paper grade: corrugated medium

Trim width: 4200 mm

Speed: 600 m/min

Grammage: 90 - 220 gsm

Machine drive: sectional drive by DC motor and reducer

Equipped with size press

Location Asia, drive 60 HZ

 

Fourdrinier 4200 mm 550 t/d

Papiermaschine Fourdrinier 2500 mm

Gebrauchte Langsieb Papiermaschine

Antriebe 60 Hz! 

 

Trim width: 2500 mm

Working speed: 150 - 350 m/min

Design speed: 400 m/min

Capacity: 120 t/d

Basis weight: 90 - 215 gsm

Drive: sectional drive BYDC and AC motor, belt pulley and reducer

Fourdrinier 2500 mm 120 t/d

Kraftliner Karton Papiermaschine 2950 mm

 Kraftliner paper machine 2950 mm

Basis Weight: 170 g/m² - 500 g/m²

Machine speed: 120 m/min (200 g/m²)

Paper Width: 2,950 mm

Capacity: 100 tpd

      

2950 mm 100 tpd

Kleine Papiermaschine für 500 t/Monat

Product: 100% recycled papers / Schrenz, Fluting, Coreboard
Grammage range: 80-240 gsm
Raw Material: wastepaper
Monthly capacity: 500 ton
fourdriner 500 tons/month

Paper production line for grapic papers with stock preparation 450 t/day

- Stock preparation system for waste paper, vacuum system, heat recovery and bleaching line are included!

-  Fourdrinier paper machine  
- Coating machine 

- 2 Prewinders
- 3 Winders (2 production winders, 1 Doctor winder)
- Pipes, tanks, towers and valves
- Electrical equipment including transformers  
- 2 Overhead cranes
- All spare parts including rolls

European Fourdriner 5 - 6 m 450 t/day

Papiermaschine für Dekorpapiere 2280 mm

Used paper machine

Trim width:                                         2280 mm

Speed:                                               600 m/min - 900 possible

Grammage range:                             45 – 200 GSM

 

Scope of supply: Approach flow system, paper machine,

Fourdriner 2280 mm 600 m/min 45 -200 GSM

Papiermaschine für Fluting und Testliner 2800 mm

Gebrauchte Papiermaschine für Fluting und Testliner 

2800 mm beschnittene Arbeitsbreite

200  t/24 h Kapazität

Mit Konstantteil

Verkauf ohne Stoffaufbereitung, diese kann separat geliefert werden. 

European Fourdriner 2800 mm net width 200 t/day

Two wire paper machine

Two wire paper machine for sale. Width over 4000 mm

Double ply paper machine, with 2 fourdriniers and headboxes.

Currently producing brown paper for containerboard: 

• 50% High Performance Fluting

• 5% Waste Based Fluting

• 30% Test Liner 1

• 15% Test Liner 3

With a weight range between 115 and 200 gsm

The following are the main PM characteristics for PM

• Operating speed up to 720 m/min

• Max drive speed 750 m/min

• Design speed dryer section 1000 m/min

• Max saleable width after rewinder 4640 m/min

European over 4000 mm

Papiermaschine für Fluting 2500 mm

Asian Foundrinier 2500 mm 120 t/day