Verkaufsliste
Hauptbild | Name | Hersteller | Typ | Größe | Kapazität | ||||||||||||||||||||||||||||||||||||||||||||||||||
---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
2 verfügbar |
Ausschusspulper ca 20 m³Ausscusspulper aus Edelstahl, ca 4 m breit, 2 Auflöseaggregate |
— | — | ca 20 m³ | — | ||||||||||||||||||||||||||||||||||||||||||||||||||
— | Trockenzylinder 2750 mm Ballenlänge, 3 bar |
— | — | 2750 mm bale length, 3300 mm bearing distance | 3 bar | ||||||||||||||||||||||||||||||||||||||||||||||||||
1 verfügbar |
Transportband / Förderband / Beschickungsband 5000x800mm |
— | — | 5000 x 800 mm | — | ||||||||||||||||||||||||||||||||||||||||||||||||||
— | Mehrere Siebbleche für Fibersorter FS4BMehrere Ersatzsiebbleche für Fibersorter FS4B von Voith bzw. Escher-Wyss in gebrauchtem oder unbenützen Zustand.
|
— | FS4B | — | — | ||||||||||||||||||||||||||||||||||||||||||||||||||
1 verfügbar |
Paper machine 2550 mmmachine width: 2550mm Max. speed: 200 m/min BW range: 30-400grs/m² Supply voltage: 3 x 500 Volts Steam pressure: 4 bar Air pressure: 7 bar Water pressure: 2 bar Water consumption: 40 Lts/Kg Steam consumption: 3.0 Kg/kg PM only from headbox to pope-roll.
MACHINE DESCRIPTION Has produced a wide range of products: Production range is from 30 to 400 GSM running at 50 to 220 m/min. Paper with at reel is 2550 mm max. Capacity is up to 3500 Kg/h. Main characteristics is its formation uniformity CM and MD, gradual drying rate both wet and steam dried. GENERAL DESCRIPTION FORMING SECTION WITH DANDY ROLL It is a Fourdrinier type with removable table for wire change, cantilever couch roll, closed headbox for optimal flow rate at any speed and watermarking Dandy Roll. PRESSES Three 80 kg /cm2 presses, 2 lower felt and a 3rd upper felt, allowing good drying capacity and surface smoothing. Water content after presses is about 50% below 120 GSM. DRYING Consist in a main battery of 18 driers of 1250 mm diameter, in 3 drive sections with drying felts on both sides. Post drying after size press is done with 6 driers, 4 of 1000mm dia and 2 1250mm diameter in one drive section, with automatic paper moisture control. All driers tested at 4 Bar, heated with steam at 3.7 Bars max. All sections covered by a recovery heat hood that allows pocket ventilation at 90 degrees Celcius. SIZE PRESS Two rubber 350 mm diameter rolls working at 20 Kg/cm allows sizing with starch and latex. CALENDER STACK Küsters 400mm dia King roll, 2 intermediate 330mm dia rolls and un upper 400mm dia Queen roll that can be used as a one pass or three pass calender up to 80 Kg/cm. MACHINE DRIVE It is a line shaft with conical pulleys, pneumatic clutch and angular reducer for 11 sections. Motor drive is 300 Kw dc. SECURITY PAPER MACHINE
|
— | — | 2550mm | 3,5 t/h | ||||||||||||||||||||||||||||||||||||||||||||||||||
1 verfügbar |
Pulper 4m³ |
— | Pulper 4 m³ | 4 m³ | — | ||||||||||||||||||||||||||||||||||||||||||||||||||
1 verfügbar |
Farbrohrstoffbehälter 70m³Gebrauchter Farbrohrstoffbehälter 70m³: 4 Behälter Tanks mit Rührwerk |
— | — | — | 70m³ | ||||||||||||||||||||||||||||||||||||||||||||||||||
1 verfügbar |
Hochkonsistenzpulper 30 m³ |
— | 30 m³ High consitency pulper | 30 m³ | — | ||||||||||||||||||||||||||||||||||||||||||||||||||
1 verfügbar |
Bütte ca. 30m³Stainless steel |
— | — | about 30m³ | — | ||||||||||||||||||||||||||||||||||||||||||||||||||
1 verfügbar |
Papiermaschine Fourdrinier 2500 mmGebrauchte Langsieb Papiermaschine Antriebe 60 Hz!
Trim width: 2500 mm Working speed: 150 - 350 m/min Design speed: 400 m/min Capacity: 120 t/d Basis weight: 90 - 215 gsm Drive: sectional drive BYDC and AC motor, belt pulley and reducer |
— | Fourdrinier | 2500 mm | 120 t/d |